⚠️ Audi Q5 — High misfuel risk
NZ Q5 TDI models are common; petrol in the diesel tank is the usual misfuel. Do not start the engine — common-rail HPFP lubrication relies on diesel. Even a short run can damage the pump and injectors.
If the engine was not started
Do not start the engine or turn the ignition to RUN. Do not drive. Arrange NZIFDA-certified drainage before contamination reaches the high-pressure pump. Keep receipts for contaminated fuel disposal (regional council under the Resource Management Act 1991 duty of care).
If the engine was started
If the engine ran on petrol in a TDI, expect inspection of the high-pressure pump, injectors, fuel rail, filters, and low-pressure lines. VW Group warranty excludes misfuel damage; follow ELSA repair scope and consider insurer or Motor Vehicle Disputes Tribunal routes for disputes.
⚠️ Audi position — Q5
Volkswagen Group ELSA requires draining via fuel cart before tank removal where needed. Misfuel damage is excluded from warranty. Follow anti-static and fire precautions in the Health and Safety at Work (Hazardous Substances) Regulations 2017 workshop controls.
Vehicle information
| Specification | Details |
|---|---|
| Make | Audi |
| Model | Q5 |
| Market status | Sold new in New Zealand — current and recent generations |
| Body styles | SUV |
| Generations | 8R (2008–2017), FY (2017–present) |
| Engines | Petrol: 2.0 TFSI, 3.0 TFSI (variants); Diesel: 2.0 TDI, 3.0 TDI; Hybrid: TFSI e PHEV; Electric: Q5 e-tron (where offered) |
| Fuel tank capacity | Approx. 70 L |
| Fuel system | MLB Evo; common-rail diesel with SCR/AdBlue on many NZ TDIs |
| Access method | Fuel pump/sender module access under rear seat (most hatchbacks/saloons) — consult ELSA for your bodystyle |
| Anti-siphon | Yes — filler-neck anti-siphon or capless filler on many NZ models; neck siphoning is not an ELSA procedure. |
| OEM service portal | VW Group erWin / ELSApro (authorised workshop subscription) |
OEM access procedure
- Disconnect the 12 V battery negative terminal and ensure the ignition is OFF (avoid fuel pump priming on key-on).
- Relieve fuel system pressure per VW Group ELSA — open filler cap briefly only if the procedure allows.
- Remove rear seat cushion and access panel to reach the in-tank pump/sender module.
- Drain contaminated fuel through the approved module ports using a fuel cart; capture waste under HSWA 2015 and Hazardous Substances Regulations and duty of care under the Waste Minimisation Act 2008 rules.
- Replace fuel filter(s) as specified; inspect seals on the pump module.
- Refill with the correct NZ-grade fuel (91 octane petrol (E10 where supplied) or diesel to NZ diesel specification); prime the low-pressure circuit per ELSA.
- Reconnect battery, clear fault codes, and road-test after checking for leaks.
Related models
Frequently asked questions
What should I do if I put petrol in my Audi Q5 diesel?
Do not start the engine. Petrol in diesel destroys HPFP lubrication on common-rail TDIs. Call a NZIFDA-certified technician to drain the tank via the OEM access method and dispose of waste fuel legally.
Can I drive my Q5 to the garage after misfuelling?
No — even a few hundred metres can draw petrol into the high-pressure system. Recovery without starting is the safest option.
Will Audi honour the warranty after misfuel?
No — fuel contamination is treated as misuse. Repairs are customer or insurance funded; keep drainage invoices for any claim.
What if I put diesel in my petrol Audi Q5?
Do not start the engine. Diesel is heavier and can foul injectors or spark ignition systems once running. Drain and flush per ELSA before restart.
Need certified fuel contamination service?
Find an NZIFDA certified operator or read consumer guidance on wrong-fuel incidents.
Find an operatorFor consumers